A model for Optimal Pricing and Ordering Strategies for Perishable Goods with Delayed Deterioration, Two-Stage Demand, and Partial Backorders under Delayed Payment Acceptance
DOI:
https://doi.org/10.56919/usci.2432.002Keywords:
economic order quantity, non-instantaneous deteriorating items, linear holding cost, two-level pricing strategies, constant partial backlogging rate, trade credit policy, two-phase demand ratesAbstract
Study’s Excerpt/Novelty
- This study introduces a novel economic order quantity (EOQ) model for managing non-instantaneous deteriorating items under two-phase demand rates and linear holding costs, incorporating constant partial backlogging and two-level pricing strategies within a trade credit framework.
- The model uniquely addresses the complexities of time-dependent quadratic demand before deterioration and constant demand afterward, providing optimal solutions for maximizing total profit by determining the best timing for positive inventory, cycle length, and order quantity.
- The research not only establishes the theoretical existence and uniqueness of these optimal solutions but also demonstrates practical implications through numerical examples and sensitivity analyses, highlighting the critical impact of deterioration rates on inventory management and profitability.
Full Abstract
This research developed an economic order quantity model for non-instantaneous deteriorating items with two-phase demand rates, linear holding cost, constant partial backlogging rate and two-level pricing strategies under trade credit policy. It is assumed that the holding cost is linear time-dependent, the unit selling price before deterioration sets in is greater than that after deterioration sets and the demand rate before deterioration sets in is considered as continuous time-dependent quadratic, after which it is considered as constant up to when the inventory is completely exhausted. Shortages are allowed and partially backlogged. The purpose of the model is to determine the optimal time with positive inventory, cycle length and order quantity such that the total profit of the inventory system has a maximum value. The necessary and sufficient conditions for the existence and uniqueness of the optimal solutions have been established. Some numerical examples have been given to illustrate the theoretical result of the model. Sensitivity analysis of some model parameters on the decision variables has been carried out and suggestions towards maximising the total profit were also given. , it is seen that the higher the rate of deterioration the lower the optimal time with positive inventory ( ), cycle length order quantity and the total profit and vice versa. This implies that the retailer needs to take all the necessary measures to avoid or reduce deterioration to maximise higher profit. Based on the results application of the model led to an increase in revenue.
References
Aggarwal, S. P. and Jaggi, C. K. (1995). Ordering policies of deteriorating items under permissible delay in payments. Journal of the Operational Research Society, 46(5), 658–662. https://doi.org/10.1057/palgrave.jors.0460509
Babangida, B. and Baraya, Y. M. (2018). An inventory model for non-instantaneous deteriorating item with time dependent quadratic demand under trade credit policy. Journal of the Nigerian Association of Mathematical Physics, 47(4), 93–110.
Babangida, B. and Baraya, Y. M. (2019). An inventory model for non-instantaneous deteriorating item with time dependent quadratic demand and linear holding cost under trade credit policy. ABACUS: Journal of the Mathematical Association of Nigeria, 46(1), 191–217.
Babangida, B. and Baraya, Y.M. (2019). An inventory model for non-instantaneous deteriorating item with time dependent quadratic demand and complete backlogging under trade credit policy. ABACUS: Journal of the Mathematical Association of Nigeria, 46(1), 488–505.
Babangida B. and Baraya Y. M. (2020). An inventory model for non-instantaneous deteriorating items with time dependent quadratic demand, two storage facilities and shortages under trade credit policy. International Journal of Modelling in Operations Management, 8(1), 1-44. https://doi.org/10.1504/IJMOM.2020.108893
Babangida B. and Baraya Y. M. (2021a). An EOQ model for non-instantaneous deteriorating items with two-phase demand rates and two level pricing strategies under trade credit policy. Transaction of the Nigerian Association of Mathematical Physics, 17(4), 117-130.
Babangida B. and Baraya Y. M. (2021b). An EOQ model for non-instantaneous deteriorating items with time dependent quadratic rate, linear holding cost and partial backlogging rate under trade credit policy. Transaction of the Nigerian Association of Mathematical Physics, 17(4), 131-144.
Babangida B. and Baraya Y. M. (2022). An EOQ model for non-instantaneous deteriorating items with two-phase demand rates, linear holding cost and time dependent partial backlogging rate under trade credit policy. ABACUS: Journal of the Mathematical Association of Nigeria, 49(2), 91-125.
Babangida, B., Baraya, Y. M., Ohanuba, O. F., Hali, A. I. and Mustapha, L. M. (2023).An Order Inventory Model for Delayed Deteriorating Items with Two-Storage Facilities, Time-Varying Demand and Partial Backlogging Rates Under Trade-Credit Policy. UMYU Scientifica, 2(1), 336-341. https://doi.org/10.56919/usci.2123.014
Baraya, Y. M. and Sani, B. (2013). An EOQ model for delayed deteriorating items with inventory level dependent demand rate and partial backlogging. Journal of the Nigerian Association of Mathematical Physics, 25(2), 295–308.
Bello, Y. and Baraya, Y. M. (2018). An inventory model for non-instantaneous deteriorating item with two-phase demand rate and partial backlogging. Journal of the Nigerian Association of Mathematical Physics, 47(4), 77–86.
Bhaula, B., Dash, J.K. & Rajendra Kumar, M. An optimal inventory model for perishable items under successive price discounts with permissible delay in payments. OPSEARCH 56, 261–281 (2019). https://doi.org/10.1007/s12597-018-0349-6.
Choudhury, K. D., Karmakar, B., Das, M. and Datta, T. K. (2013). An inventory model for deteriorating items with stock dependent demand, time-varying holding cost and shortages. Journal of the Operational Research Society, 23(1), 137–142. https://doi.org/10.1007/s12597-013-0166-x.
Geetha, K. V. and Uthayakumar, R. (2010). Economic design of an inventory policy for non-instantaneous deteriorating items under permissible delay in payments. Journal of Computational and Applied Mathematics, 233(10), 2492–2505. https://doi.org/10.1007/s40819-015-0053-7.
Geetha, K. V. and Udayakumar, R. (2016). Optimal lot sizing policy for non-instantaneous deteriorating items with price and advertisement dependent demand under partial backlogging. International Journal of Applied and Computational Mathematics, 2(1), 171–193. https://doi.org/10.1007/s40819-015-0053-7
Goyal, S. K. (1985). EOQ under conditions of permissible delay in Payments. Journal of the Operational Research Society, 36(4), 335–338. https://doi.org/10.1057/jors.1985.56.
Haley, C. W. and Higgins, R. C. (1973). Inventory policy and trade credit financing. Management Science, 20(4), 464–471. https://doi.org/10.1287/mnsc.20.4.464.
Mahato and Mahata, G. C. (2023). Optimal ordering policy under order-size dependent trade credit and complete backlogging derived algebraically. OPSEARCH, 60, 420-444. https://doi.org/10.1007/s12597-022-00614-z.
Majunder, P. and Kumar, U. B. (2019). An EPQ model of deteriorating substitute items under trade credit policy. International. Journal of .Operational research, 34(2), 161-212. https://doi.org/10.1504/IJOR.2019.10018752,
Mohsen Lashgari, Ata Allah Taleizadeh and Seyed Jafar Sadjadi (2018). Ordering policies for non-instantaneous deteriorating items under hybrid partial prepayment, partial trade credit and partial backordering. Journal of the Operational Research Society, 69(8), 1167-1196. https://doi.org/10.1080/01605682.2017.1390524
Mustapha. L. M, and Majid, K. M. (2023). A Production inventory model for non-instantaneous deteriorating items with two phase production period stock-dependent demand and shortages, International Journal of Mathematics in Operational Research, 24(2), 173-193. https://doi.org/10.1504/IJMOR.2023.129432.
Nath, B. K. and Sen, N. A. (2022). Partially Backlogged Inventory Model for Time-Deteriorating items Using Penalty Cost. Operation Research Forum3,62. http://doi.org/10.1007/s43069-022-00173-5.
Sakar, B. and Sakar, S. (2013). An improved inventory model with partial backlogging, time-varying deterioration and stock-dependent demand. Economic Modelling, 30(1), 924–932. http://doi.org/10.1016/j.econmod.2012.09.049
Sheng-Chih Chen & Jinn –Tsair Teng (2014).Retailers optimal ordering policy for deteriorating items with maximum lifetime under suppliers trade credit financing. Applied Mathematical Modelling 38(2014), 4049-4061. http://doi.org/10.1016/j.apm.2013.11.056.
Soni, H.N., Chauhan, A.D. Joint pricing, inventory, and preservation decisions for deteriorating items with stochastic demand and promotional efforts. J Ind Eng Int 14, 831–843 (2018). https://doi.org/10.1007/s40092-018-0265-7
Tiwari, S., Cardenas-Barron, L. E., Shaikh, A. A. and Goh, M. (2022). Retailers’ optimal ordering policy for deteriorating items under order-size dependent trade credit and complete backlogging. Computer and Industrial Engineering, 139(10), 55-59. http://doi.org/10.1016/j.cie.2018.12.006.
Tripathy, M., Sharma, G. and Sharma, A. K. (2022). An inventory model for non-instantaneous deteriorating item with constant demand under progressive financial trade credit facility. OPSEARCH, 59, 1215-1243. https://doi.org/10.1007/s12597-022-00573-5.
Umakanta, M. and Chaitanya, K. T. (2012). An inventory model for time dependent Weibull deterioration with partial backlogging. American Journal Of Operational Research, 2(2), 11-15. http://doi.org/10.5923/j.ajor.20120202.02.
Umakanta Mishra, Jacobo Tijerina-Aguilera, Sunil Tiwari, Leopoldo Eduardo Cárdenas-Barrón (2018). Retailer’s Joint Ordering, Pricing, and Preservation Technology Investment Policies for a Deteriorating Item under Permissible Delay in Payments, Mathematical Problems in Engineering, vol. 2018, Article ID 6962417, 14 pages, 2018. https://doi.org/10.1155/2018/6962417.
Downloads
Published
How to Cite
Issue
Section
License
Copyright (c) 2024 UMYU Scientifica
This work is licensed under a Creative Commons Attribution-NonCommercial 4.0 International License.
&
